1-800-315-4345
Goodman 5 Ton 15.5 SEER2 Dual Fuel System Overview
This AHRI-certified dual fuel system (Certificate #215447303) pairs the Goodman GZV6SA6010 5-ton R-32 variable-speed heat pump with the GRVT800804CN 80,000 BTU/h 80% AFUE gas furnace and the CAPEA6030D3 cased upflow/downflow evaporator coil. Rated at 15.5 SEER2 and 8.2 HSPF2, this matched system delivers efficient year-round comfort by automatically switching between electric heat pump operation and gas furnace heating based on outdoor conditions. Note: If you would like to review the manufacturer Product Specifications, Warranty, Brochure, etc., for this system, please refer to the 'Resources (System Manuals and Warranty)' Tab above on this page.
System Components
- GZV6SA6010 — 5-Ton R-32 Variable-Speed Inverter-Driven Split System Heat Pump. Side discharge configuration with variable-speed swing compressor, EEV metering, and 118 oz. factory R-32 charge. 208-230V/1Ph/60Hz electrical. Dimensions: 37" W x 12-5/8" D x 39" H. Equipment Weight: 168 lbs.
- CAPEA6030D3 — 5-Ton R-32 Cased Upflow/Downflow Cased Evaporator Coil with EEV expansion device. Upflow/Downflow configuration. Cabinet Dimensions: 24-1/2" W x 21" D x 30" H. Ship Weight: 78 lbs. Aluminum coil construction.
- GRVT800804CN — 80,000 BTU/h Input (64,000 BTU/h Output) 80% AFUE Two-Stage Natural Gas Gas Furnace. Variable-Speed ECM circulator blower motor. Downflow configuration. Cabinet Dimensions: 21" W x 28" D x 33-3/8" H. Category I (Natural Draft / Induced Draft) venting (4").
Pro-Installer Tip
Technical Friction: Downflow furnace installations with this 80,000 BTU two-stage gas furnace require careful attention to combustion air routing and condensate management. In tight closet or garage applications, the 21" cabinet width can create clearance conflicts with the R-32 refrigerant line connections on the CAPEA6030D3 evaporator coil above.
Long-Term Prevention: Verify the condensate trap is installed per manufacturer instructions and confirm the drain slope before startup. R-32 systems operating at higher discharge pressures than R-410A predecessors will produce more condensate at peak cooling. A failed drain in a downflow application means water damage to the heat exchanger and burner assembly — the most expensive callback in HVAC.
Expert Validation: Use a digital manometer to confirm negative pressure in the combustion chamber during operation. Target -0.02" to -0.10" W.C. at the draft inducer outlet. Document this reading on the commissioning report alongside your micron gauge evacuation record (500 microns or below, held for 10 minutes minimum with R-32).
Professional Standard: This system uses R-32 refrigerant (GWP 675), which is classified as A2L (mildly flammable). Ensure compliance with ASHRAE 15 and local mechanical codes for A2L refrigerant charge limits in occupied spaces. Many jurisdictions now require leak detection equipment for A2L installations.
Key Performance Benefits
- Dual Fuel Efficiency: Combines 15.5 SEER2 / 8.2 HSPF2 heat pump performance with 80% AFUE gas furnace backup, automatically selecting the most cost-effective heating source based on outdoor conditions.
- R-32 Low-GWP Refrigerant: R-32 has a Global Warming Potential (GWP) of 675 — approximately 68% lower than R-410A (GWP 2088). R-32 also provides approximately 10% better volumetric cooling capacity, contributing to system efficiency gains.
- Variable-Speed Compressor Technology: The inverter-driven variable-speed swing compressor modulates output from approximately 25% to over 100% capacity, matching the exact thermal load for reduced energy consumption and tighter temperature control (±1°F) compared to single-stage or two-stage systems.
- Precise Airflow Management: The Variable-Speed ECM blower motor provides optimized airflow across heating, cooling, and continuous fan modes, reducing hot/cold spots and lowering operating noise compared to PSC motors.
- Two-Stage Gas Valve: Two-stage gas valve operates at 70% capacity on low fire for most heating demand, reducing temperature swings and gas consumption while reserving full output for the coldest conditions.
- AHRI Certified Match: All components are AHRI-certified as a matched system (Certificate #215447303), ensuring rated performance is achieved when installed according to manufacturer specifications.
Technical Specifications
| System Performance Ratings (AHRI #215447303) | |
|---|---|
| SEER2 | 15.5 |
| EER2 | 8.5 |
| HSPF2 | 8.2 |
| Furnace AFUE | 80% |
| System Cooling Capacity | 53,500 BTU/h |
| System Heating Capacity (HP @ 47°F) | 54,500 BTU/h |
| Furnace Heating Input | 80,000 BTU/h |
| Refrigerant | R-32 |
| Coil-to-Furnace Fit | 1.75" Offset |
| Outdoor Unit — GZV6SA6010 | |
| Dimensions (W x D x H) | 37" x 12-5/8" x 39" |
| Equipment / Ship Weight | 168 lbs / 198 lbs |
| Electrical | 208-230V / 1 Phase / 60 Hz |
| MCA / MOP | 31.8A / 37.5A |
| Evaporator Coil — CAPEA6030D3 | |
| Configuration | Upflow/Downflow |
| Dimensions (W x D x H) | 24-1/2" x 21" x 30" |
| Ship Weight | 78 lbs |
| Gas Furnace — GRVT800804CN | |
| Configuration | Downflow |
| Dimensions (W x D x H) | 21" x 28" x 33-3/8" |
| Ship Weight | 118 lbs |
| Venting | Category I (Natural Draft / Induced Draft) — 4" diameter |
| Note: See 'Resources (System Manuals and Warranty)' Tab above for full specifications. | |
Compliance & Environmental Data
| Category | Details |
|---|---|
| Refrigerant Type | R-32 (Difluoromethane) |
| Refrigerant GWP | 675 (approximately 68% lower than R-410A) |
| ASHRAE Safety Classification | A2L (Lower Flammability) |
| EPA Section 608 Certification | Required for all technicians handling R-32 refrigerant |
| Regional Compliance | Natural Gas — Standard NOx emissions; verify local air quality district requirements |
| Federal Tax Credit Eligibility | No |
| AHRI Certification | Yes — Certificate #215447303 |
| Energy Star (Heat Pump) | No |
Warranty & Registration
Each component in this system carries its own manufacturer warranty. All warranties require online registration at www.goodmanmfg.com within 60 days of installation. Registration is not required in California, Florida, or Québec. Warranty durations may differ in Texas and Florida.
- Outdoor Heat Pump (GZV6SA6010): 10-Year Parts Limited Warranty; 10-Year Unit Replacement Limited Warranty (registered). One-time Compressor Replacement coverage available for years 11–99 through an ASURE Extend Service Plan. Without registration, warranty coverage is limited to 5 years.
- Evaporator Coil (CAPEA6030D3): 10-Year Parts Limited Warranty (registered). Without registration, warranty coverage is limited to 5 years. Coil must be matched with an approved outdoor unit to maintain warranty eligibility.
- Gas Furnace (GRVT800804CN): Lifetime Heat Exchanger Limited Warranty (good for as long as the original homeowner owns the home, registered); 10-Year Unit Replacement Limited Warranty; 10-Year Parts Limited Warranty (registered). Without registration, warranty coverage is limited to 5 years. The heat exchanger warranty is contingent upon proper installation and annual professional maintenance.
Refer to each component's warranty documentation for complete terms, conditions, limitations, and exclusions. Warranty claims require proof of proper installation by a licensed HVAC contractor and evidence of timely registration.
Let customers speak for us
I absolutely love how easy it is to use and how well they fit and look. Awesome!!
Excellent. Placed unit in a two room cabin with each inside unit on the same common wall. Outside temps were in the low 40’s and the cabin was quickly warmed.
Very easy to install, and with a little trouble shooting with help from tech. it was very quietly putting out ice cold air... Had a bad fuse in my disconnect....
This is a good air conditioner for the price. Our apartment living room and kitchen have been kept nice and cool. The complex we moved into actually already had these installed but I have been so happy with the performance I purchased one for my mom who lives in a tiny home, I'm an HVAC tech and it was about time to replace her HVAC. Yes, I recommend this.
We have zero regrets! No wait, one. That we didn’t get them sooner! We (my husband, self and 19yr old son) work outside noon-8am several days a week in Texas. It doesn’t matter how low you set your AC unit it’s just never enough and it just runs it into the ground. We finally decided to pull the plug. In my 40 years I’ve never slept so good. It’s like hotel good but in your own bed!!! Install was super easy because I watched him do it, LOL. I kid. I’ll ask for his install input and update but seriously he installed all 4 (3 bedrooms and 1 living room) in 2 days. Probably wouldn’t have taken so long if he didn’t have to pour a pad for them but it was well worth it! Last pic is from the Nest. They were installed Friday. Compare usage from Sat & Sun to before we got them! Insane!!!
This was best investment I've ever made. I put this on the wall on my porch that I've converted to a sun room. This extra space that I enclosed with plexiglass and wood and sealed with insulation stayed about 20 degrees different from out side. With a window unit and heaters. Now with the split unit it stays what ever temp I want it to be. The della split unit is so quite I have to put my ear on it to hear it run sometimes the out side unit is even quite. If you mount on outside wall that is a little thin and only a few inches thick it might give a little bit of a hum but so slight you have to want to hear it. Turbo cool or heat will cool or heat super fast. The system is perfect 👌 👍 🥰. I love it.
I live in Florida and our summers are brutal. I installed this in my garage.
It wasn’t a hard install but it took my dad and I about 8 hours. He ran the electrical.
Around this time of the year, my garage is around 82 degrees and +70% humidity, the air is very wet.
This morning it was 74” and 52% humidity.
The indoor and outdoor units are remarkably quieter compared to our house’s HVAC system.
I bought and installed 2 of the della mini splits in the last 8 months, one for my double wide 1800 sqf that I am remodeling little by little, and another for my daughters craftsman home. What an improvement! So silent! So efficient! So easy of operating. For the last 10+ years, we have been using windows AC units and radiant heaters after our central heat and air system broke. The suffering is over. We are saving $100 a month on the power bill and enjoying ourselves inside now. Our Great Pyrenees friends are enjoying the AC's too during the scorching hot summer days. They are pretty easy to install. Follow the instructions on the book and watch some videos on YouTube. On the second install, I made an electrical mistake and purchased the wrong breaker. I am only a landscaper by the way. No problem! I called the technical support number and a very nice tech called me back after just a few hours and figured it out by phone within 5 minutes. It is all great! We just keep it simple by using the remotes. I love the delay timer option. Now that the weather is cooling down (80's max), I set the timer so it doesn't come ON automatically before 12 pm. By the time the girls come from school, 75°f is back as set. GREAT PRODUCT, GREAT TECHNICAL SUPPORT
Installation was a breeze. Unit is working flawlessly. I love that it connected to my Alexa and I can voice control or use the Della app. I am going to purchase a second Della for our guest home.
Got these panels for my backyard as the wall for the Composting area. Black is good for absorbing the heat of the sun and is easy to hide the ugly things. It is a good quality product. The foot support is stainless steel and long enough to bind the ground and the panels. As it is with a good quality, it is just a little heavy, which may require two people to move around or install it.
Solid plastic material. Assembly was easy with a power screwdriver. Looks better than an ugly air conditioner unit.
Great value and just the right size. Note that if you want to place them in a straight line, you will need to use an electric screwdriver to tighten the screws.
Made from good quality materials. Very easy to install and assemble. Looks great to hide the trash bins. Would buy more for AC.
I use it to cover the trash can. It is very practical. This way you can't see the dirty surface of the trash can. I strongly recommend it.
Great product. Installation was very easy
What customers think about the store
Store offers excellent customer service with fast shipping and competitive pricing. Products arrive well-packaged and on time. Knowledgeable support staff assist with installations and technical questions. Customers appreciate quality HVAC systems, mini-splits...