1-800-315-4345
Goodman 5 Ton 15.2 SEER2 Dual Fuel System Overview
This AHRI-certified dual fuel system (Certificate #215447304) pairs the Goodman GZV6SA6010 variable-speed heat pump condenser with the GRVS960805CU 96% AFUE gas furnace and CAPEA6030C3 evaporator coil. The system uses R-32 refrigerant with a Global Warming Potential (GWP) of 675 — approximately 68% lower than R-410A — and achieves up to 15.2 SEER2 and 8.2 HSPF2 ratings. The outdoor unit delivers up to 53,500 BTU/h in cooling and 54,500 BTU/h in heat pump heating at 47°F, while the gas furnace provides up to 80,000 BTU/h input for supplemental and emergency heating. This system operates in standard (non-communicating) mode.
Note: If you would like to review the manufacturer Product Specifications, Warranty, Brochure, etc., for this system, please refer to the 'Resources (System Manuals and Warranty)' Tab above on this page.
System Components
- GZV6SA6010 — Goodman 5 Ton Variable-Speed Side Discharge Heat Pump Condenser (R-32, EEV, 37" W x 12⅝" D x 39" H)
- GRVS960805CU — Goodman 80,000 BTU/h 96% AFUE Single-Stage Variable-Speed ECM Gas Furnace (Upflow/Horizontal, 21" Cabinet, Ultra-Low NOx)
- CAPEA6030C3 — Goodman Upflow/Downflow Cased Evaporator Coil with EEV (21" W x 21" D x 30" H)
Pro-Installer Tip
Technical Friction: Dual fuel changeover calibration between heat pump and gas furnace demands precision. If the balance point is set incorrectly, the system will short-cycle between modes, increasing component wear and creating uneven temperatures — especially in shoulder seasons when outdoor temps hover near the switchover threshold.
Long-Term Prevention: During commissioning, verify the balance point setting matches the regional heating design temperature. On R-32 systems with variable-speed compressors, the heat pump can operate efficiently to lower ambient temperatures than legacy R-410A systems. Setting the balance point 5–10°F lower than traditional defaults can reduce gas consumption by 15–25% over a heating season while keeping the home comfortable.
Expert Validation: Use a digital manifold gauge set rated for R-32 (up to 750 PSI high-side) and verify subcooling at 9±1°F per manufacturer specification. Confirm communicating mode handshake between the outdoor unit, indoor coil, and thermostat using the onboard 7-segment LED diagnostic display. Document all readings with a timestamped commissioning report.
Professional Standard: R-32 is classified as an A2L (mildly flammable) refrigerant under ASHRAE 34. Ensure compliance with local mechanical codes for A2L refrigerant charge limits in occupied spaces. Many jurisdictions adopting the 2024 UMC or IMC now require R-32-rated leak detection in mechanical rooms. Verify EPA Section 608 certification covers A2L handling before charging.
Key Performance Benefits
- High-Efficiency Cooling & Heating: Up to 15.2 SEER2 / 8.3 EER2 / 8.2 HSPF2 ratings verified through AHRI certification (#215447304), delivering dependable seasonal performance across varying climate conditions.
- Next-Generation R-32 Refrigerant: R-32 has a GWP of 675, approximately 68% lower than R-410A (GWP 2,088). This translates to reduced environmental impact while maintaining comparable thermodynamic efficiency, and positions the system for long-term regulatory compliance.
- Variable-Speed Compressor Technology: The GZV6SA6010 uses a variable-speed swing compressor that modulates capacity to match real-time load demands. This reduces energy consumption during part-load conditions, minimizes temperature swings, and improves whole-house humidity control compared to single-speed or two-stage systems.
- Quiet Operation: Three-level quiet mode allows sound suppression down to 45 dBA sound pressure at 3 feet. The digitally commutated fan motor and high-density compressor sound blanket further reduce operational noise — a measurable improvement for installations near bedrooms, patios, and property lines subject to local noise ordinances.
- Dual Fuel Versatility: Automatic switchover between electric heat pump and gas furnace heating based on outdoor temperature and balance point settings. This maximizes efficiency by using the heat pump during moderate weather and gas heating only when it is more cost-effective at lower temperatures.
Technical Specifications
| Specification | Value |
|---|---|
| AHRI Certificate Number | 215447304 |
| System Type | Dual Fuel System |
| Nominal Capacity | 5 Ton (60,000 BTU/h Nominal) |
| SEER2 Rating | 15.2 |
| EER2 Rating | 8.3 |
| HSPF2 Rating | 8.2 |
| Max Cooling Capacity | 53,500 BTU/h at 95°F |
| Max Heating Capacity (47°F) | 54,500 BTU/h |
| Max Heating Capacity (5°F) | 33,000 BTU/h |
| Refrigerant Type | R-32 |
| Factory Charge | 118 oz |
| Expansion Device | EEV (Electronic Expansion Valve) |
| Compressor Type | Variable-Speed Swing |
| Outdoor Unit — GZV6SA6010 | |
| Dimensions (W x D x H) | 37" x 12⅝" x 39" |
| Equipment Weight | 179 lbs |
| Electrical | 208-230V / 1 Phase / 60 Hz |
| Min. Circuit Ampacity (MCA) | 37.5A |
| Max Overcurrent Protection | 40A |
| Liquid Line | ⅜" |
| Suction Line | 1⅛" |
| Gas Furnace — GRVS960805CU | |
| AFUE | 96% |
| Input BTU/h | 80,000 |
| Gas Valve Type | Single-Stage |
| Motor | Variable-Speed ECM |
| Configuration | Upflow/Horizontal |
| Cabinet Width | 21" |
| Dimensions (W x D x H) | 21" x 28⅞" x 34½" |
| Venting | 2" - 3" PVC |
| Electrical | 120V / 1 Phase / 60 Hz |
| Evaporator Coil — CAPEA6030C3 | |
| Configuration | Upflow/Downflow, Cased |
| Dimensions (W x D x H) | 21" x 21" x 30" |
| Expansion Device | EEV (Electronic Expansion Valve) |
| Weight | 75 lbs |
| Note: See 'Resources (System Manuals and Warranty)' Tab above for full specifications. | |
Compliance & Environmental Data
| Category | Detail |
|---|---|
| Refrigerant Type | R-32 (Difluoromethane) |
| Global Warming Potential (GWP) | 675 (approximately 68% lower than R-410A at 2,088) |
| ASHRAE Safety Classification | A2L (Lower Flammability) |
| EPA Section 608 Requirements | Certified technicians required for refrigerant handling; venting prohibition applies per Clean Air Act |
| Regional Compliance | All Regions — meets DOE 2023 minimum efficiency standards |
| AHRI Certified | Yes (Certificate #{ahri}) |
| ETL Listed | Yes |
| Energy Star Cold Climate | No |
| Federal Tax Credit Eligibility (25C) | Verify eligibility with a qualified tax professional based on installed SEER2/HSPF2 ratings and current IRS requirements. |
| NOx Emissions | Ultra-Low NOx (≤14 ng/J) — meets South Coast AQMD Rule 1111 and Bay Area AQMD requirements |
Warranty & Registration
- Outdoor Unit (GZV6SA6010): 5-Year Initial Term Limited Warranty on all parts. With online registration at goodmanmfg.com within 60 days of installation, coverage extends to 10-Year Registered Additional Term Limited Warranty on all parts. Coverage applies to owner-occupied residential installations only. Registration requirements may not apply in Florida, California, or Québec. Labor, refrigerant, and freight are not covered.
- Gas Furnace (GRVS960805CU): 5-Year Initial Term Limited Warranty on all parts. With registration within 60 days, extends to 10-Year Registered Additional Term Limited Warranty on all parts. Heat exchanger warranty: if the heat exchanger fails within 10 years (registered), Goodman will furnish a new equivalent unit. The heat exchanger itself is covered for up to 20 years (replacement heat exchanger), and up to 99 years (one-time replacement), when properly registered. Owner-occupied residential installations only.
- Evaporator Coil (CAPEA6030C3): 5-Year Initial Term Limited Warranty on all parts. With online registration within 60 days, extends to 10-Year Registered Additional Term Limited Warranty on all parts. Owner-occupied residential installations only.
Let customers speak for us
I absolutely love how easy it is to use and how well they fit and look. Awesome!!
Excellent. Placed unit in a two room cabin with each inside unit on the same common wall. Outside temps were in the low 40’s and the cabin was quickly warmed.
Very easy to install, and with a little trouble shooting with help from tech. it was very quietly putting out ice cold air... Had a bad fuse in my disconnect....
This is a good air conditioner for the price. Our apartment living room and kitchen have been kept nice and cool. The complex we moved into actually already had these installed but I have been so happy with the performance I purchased one for my mom who lives in a tiny home, I'm an HVAC tech and it was about time to replace her HVAC. Yes, I recommend this.
We have zero regrets! No wait, one. That we didn’t get them sooner! We (my husband, self and 19yr old son) work outside noon-8am several days a week in Texas. It doesn’t matter how low you set your AC unit it’s just never enough and it just runs it into the ground. We finally decided to pull the plug. In my 40 years I’ve never slept so good. It’s like hotel good but in your own bed!!! Install was super easy because I watched him do it, LOL. I kid. I’ll ask for his install input and update but seriously he installed all 4 (3 bedrooms and 1 living room) in 2 days. Probably wouldn’t have taken so long if he didn’t have to pour a pad for them but it was well worth it! Last pic is from the Nest. They were installed Friday. Compare usage from Sat & Sun to before we got them! Insane!!!
This was best investment I've ever made. I put this on the wall on my porch that I've converted to a sun room. This extra space that I enclosed with plexiglass and wood and sealed with insulation stayed about 20 degrees different from out side. With a window unit and heaters. Now with the split unit it stays what ever temp I want it to be. The della split unit is so quite I have to put my ear on it to hear it run sometimes the out side unit is even quite. If you mount on outside wall that is a little thin and only a few inches thick it might give a little bit of a hum but so slight you have to want to hear it. Turbo cool or heat will cool or heat super fast. The system is perfect 👌 👍 🥰. I love it.
I live in Florida and our summers are brutal. I installed this in my garage.
It wasn’t a hard install but it took my dad and I about 8 hours. He ran the electrical.
Around this time of the year, my garage is around 82 degrees and +70% humidity, the air is very wet.
This morning it was 74” and 52% humidity.
The indoor and outdoor units are remarkably quieter compared to our house’s HVAC system.
I bought and installed 2 of the della mini splits in the last 8 months, one for my double wide 1800 sqf that I am remodeling little by little, and another for my daughters craftsman home. What an improvement! So silent! So efficient! So easy of operating. For the last 10+ years, we have been using windows AC units and radiant heaters after our central heat and air system broke. The suffering is over. We are saving $100 a month on the power bill and enjoying ourselves inside now. Our Great Pyrenees friends are enjoying the AC's too during the scorching hot summer days. They are pretty easy to install. Follow the instructions on the book and watch some videos on YouTube. On the second install, I made an electrical mistake and purchased the wrong breaker. I am only a landscaper by the way. No problem! I called the technical support number and a very nice tech called me back after just a few hours and figured it out by phone within 5 minutes. It is all great! We just keep it simple by using the remotes. I love the delay timer option. Now that the weather is cooling down (80's max), I set the timer so it doesn't come ON automatically before 12 pm. By the time the girls come from school, 75°f is back as set. GREAT PRODUCT, GREAT TECHNICAL SUPPORT
Installation was a breeze. Unit is working flawlessly. I love that it connected to my Alexa and I can voice control or use the Della app. I am going to purchase a second Della for our guest home.
Got these panels for my backyard as the wall for the Composting area. Black is good for absorbing the heat of the sun and is easy to hide the ugly things. It is a good quality product. The foot support is stainless steel and long enough to bind the ground and the panels. As it is with a good quality, it is just a little heavy, which may require two people to move around or install it.
Solid plastic material. Assembly was easy with a power screwdriver. Looks better than an ugly air conditioner unit.
Great value and just the right size. Note that if you want to place them in a straight line, you will need to use an electric screwdriver to tighten the screws.
Made from good quality materials. Very easy to install and assemble. Looks great to hide the trash bins. Would buy more for AC.
I use it to cover the trash can. It is very practical. This way you can't see the dirty surface of the trash can. I strongly recommend it.
Great product. Installation was very easy
What customers think about the store
Store specializes in HVAC systems and power solutions with competitive pricing and fast shipping. Customers praise responsive customer service, professional installation support, and product quality. Many report significant energy savings and appreciate DIY-fr...