1-800-315-4345
System Overview
This Goodman 5-Ton Dual Fuel System pairs the GZV7SA6010 variable-speed, inverter-driven R-32 heat pump condenser with the CHPEA6030D3 cased evaporator coil and the GMVS960805CU 96.0% AFUE gas furnace. The system is AHRI certified (Certificate #217495908) and rated at 15.5 SEER2 / 9.8 EER2 / 8.5 HSPF2, qualifying for the ENERGY STAR Cold Climate Certified designation.
Dual fuel operation automatically switches between electric heat pump heating and gas furnace heating based on outdoor temperature, optimizing both comfort and operating cost across a wide range of climate conditions.
Note: If you would like to review the manufacturer Product Specifications, Warranty, Brochure, etc., for this system, please refer to the 'Resources (System Manuals and Warranty)' Tab above on this page.
What’s Included
- GZV7SA6010 — Goodman 5-Ton Variable-Speed Inverter-Driven R-32 Side-Discharge Heat Pump Condenser (52,000 BTU/h Cooling / 54,000 BTU/h Heating @ 47°F)
- CHPEA6030D3 — Goodman 5-Ton Cased Horizontal Evaporator Coil, Horizontal, 21" Cabinet Depth, Internal EEV, All-Aluminum
- GMVS960805CU — Goodman 80,000 BTU/h Input 96.0% AFUE Single-Stage Upflow/Horizontal Gas Furnace, Variable-Speed ECM, Ultra Low NOx
Pro-Installer Tip: Dual Fuel Changeover and Line Set Considerations
The Technical Friction: On 5-ton dual fuel installations with R-32 refrigerant, the GZV7SA6010 uses front-and-back sealing service valves with ⅞" suction valve ports but requires 1⅛" suction line sets. Installers will need to supply ⅞" to 1⅛" adapters for suction line connections. Confirm the furnace’s upflow/horizontal configuration does not conflict with coil orientation or drain routing before committing to ductwork connections.
The Long-Term Prevention: Set the dual fuel changeover (balance point) based on local utility rate structures and climate data, not factory defaults. A misconfigured balance point leads to unnecessary gas consumption in mild shoulder seasons or over-reliance on the heat pump at sub-optimal outdoor temperatures, resulting in nuisance high-pressure lockouts after 6–12 months.
The Expert Validation: After final charge, use a digital manifold gauge with R-32 pressure-temperature charts to verify 11±1°F subcooling at the service valve. R-32’s higher operating pressures require careful leak testing with an electronic leak detector rated for A2L (mildly flammable) refrigerants.
The Professional Standard: R-32 is classified as A2L (mildly flammable, GWP 675). All installations must comply with EPA Section 608 certification requirements and ASHRAE 15/34 safety standards. Ensure adequate ventilation in confined installation spaces per local mechanical code and the unit’s installation instructions. The lower GWP of R-32 compared to R-410A supports AIM Act compliance targets.
Key System Benefits
- Variable-Speed Inverter Technology: The GZV7SA6010 uses a variable-speed swing compressor with inverter drive, modulating capacity from partial load to full output. This reduces short-cycling, lowers sound levels (as low as 45 dBA in Quiet Mode), and improves humidity control compared to single-speed systems.
- ENERGY STAR Cold Climate Certified: This system meets the EPA’s stringent Cold Climate Heat Pump criteria, meaning it maintains effective heating capacity at temperatures well below freezing—delivering 46,000 BTU/h at 5°F and supporting operation down to -10°F.
- R-32 Low-GWP Refrigerant: R-32 has a Global Warming Potential of 675, approximately 68% lower than R-410A (GWP 2,088). This supports AIM Act and EPA Phasedown compliance while delivering improved thermodynamic efficiency per pound of refrigerant.
- Electronic Expansion Valve (EEV) Metering: Both the outdoor unit and the indoor coil utilize EEV technology for precise superheat and subcooling control across all operating conditions, reducing energy waste at part-load compared to fixed-orifice systems.
- Dual Fuel Economy: Automatic switchover between heat pump and gas furnace heating based on outdoor temperature balance point. The heat pump handles moderate-weather heating at higher efficiency, while the 96.0% AFUE furnace takes over during extreme cold when electric resistance supplemental heat would be cost-prohibitive.
- Communicating System Architecture: When paired with a Goodman GTST connected thermostat, the system uses two-wire communicating protocol between indoor and outdoor components for coordinated staging, fault diagnostics, and field-selectable boost mode.
Technical Specifications
| Specification | Value |
|---|---|
| AHRI Certificate Number | 217495908 |
| System Type | Dual Fuel System |
| Nominal Capacity | 5 Ton (60,000 BTU/h) |
| SEER2 | 15.5 |
| EER2 | 9.8 |
| HSPF2 | 8.5 |
| Furnace AFUE | 96.0% |
| Refrigerant | R-32 (Charge: 162 oz.) |
| Outdoor Unit — GZV7SA6010 | |
| Max Cooling Capacity | 52,000 BTU/h @ 95°F |
| Max Heating Capacity | 54,000 BTU/h @ 47°F |
| Max Heating Capacity (Low Temp) | 46,000 BTU/h @ 5°F |
| Compressor Type | Variable-Speed Swing |
| Dimensions (W x D x H) | 37"W x 12⅝"D x 56⁵⁄₁₆"H |
| Unit Weight | 236 lbs |
| Electrical | 208-230V / 1 Phase / 60 Hz |
| MCA / MOCP | 34.4A / 40A |
| Ambient Operating Range (Cooling) | 0°F to 115°F |
| Ambient Operating Range (Heating) | -10°F to 70°F |
| Evaporator Coil — CHPEA6030D3 | |
| Configuration | Horizontal (Cased) |
| Dimensions (W x D x H) | 30" x 21" x 21" |
| Expansion Device | EEV (Electronic Expansion Valve) |
| Coil Material | All-Aluminum |
| Ship Weight | 76 lbs |
| Gas Furnace — GMVS960805CU | |
| Heating Input | 80,000 BTU/h |
| AFUE | 96.0% |
| Stages | Single-Stage |
| Configuration | Upflow/Horizontal |
| Motor | Variable-Speed ECM |
| Gas Type | Ultra Low NOx |
Note: See 'Resources (System Manuals and Warranty)' Tab above for full specifications.
Compliance & Environmental
| Requirement | Details |
|---|---|
| Refrigerant Type | R-32 (Difluoromethane) |
| GWP (Global Warming Potential) | 675 |
| ASHRAE Safety Classification | A2L (Lower Flammability) |
| EPA Section 608 Certification | Required for all technicians handling R-32 |
| AIM Act Compliance | R-32 supports EPA HFC phasedown targets (GWP well below the 700 threshold for residential AC/HP) |
| ENERGY STAR® | ENERGY STAR Cold Climate Certified |
| Regional Compliance | All Regions (A-Rating) |
| Federal Tax Credit Eligibility | Systems meeting the highest efficiency tier (CEE) may qualify for federal tax credits under the Inflation Reduction Act (25C). Verify current requirements at energystar.gov. |
Warranty & Registration
- Outdoor Unit (GZV7SA6010): 5-Year Initial Term Parts Limited Warranty. With online registration within 60 days of installation: 10-Year Unit Replacement Limited Warranty (if compressor fails, entire outdoor unit is replaced, one time) and 10-Year Parts Limited Warranty for the original registered homeowner. Registration at www.goodmanmfg.com.
- Evaporator Coil (CHPEA6030D3): 5-Year Initial Term Parts Limited Warranty. With online registration within 60 days of installation: 10-Year Parts Limited Warranty for the original registered homeowner. Registration at www.goodmanmfg.com.
- Gas Furnace (GMVS960805CU): Lifetime Heat Exchanger Limited Warranty (with registration, good for as long as you own your home). 10-Year Unit Replacement Limited Warranty and 10-Year Parts Limited Warranty with online registration within 60 days of installation. Registration at www.goodmanmfg.com.
Warranty terms vary by state and province. Online registration is not required in California, Florida, or Québec. The duration of warranty coverage in Texas and Florida may differ. Complete warranty details are available at www.goodmanmfg.com. A licensed contractor must install the system for warranty eligibility.
Let customers speak for us
I absolutely love how easy it is to use and how well they fit and look. Awesome!!
Excellent. Placed unit in a two room cabin with each inside unit on the same common wall. Outside temps were in the low 40’s and the cabin was quickly warmed.
Very easy to install, and with a little trouble shooting with help from tech. it was very quietly putting out ice cold air... Had a bad fuse in my disconnect....
This is a good air conditioner for the price. Our apartment living room and kitchen have been kept nice and cool. The complex we moved into actually already had these installed but I have been so happy with the performance I purchased one for my mom who lives in a tiny home, I'm an HVAC tech and it was about time to replace her HVAC. Yes, I recommend this.
We have zero regrets! No wait, one. That we didn’t get them sooner! We (my husband, self and 19yr old son) work outside noon-8am several days a week in Texas. It doesn’t matter how low you set your AC unit it’s just never enough and it just runs it into the ground. We finally decided to pull the plug. In my 40 years I’ve never slept so good. It’s like hotel good but in your own bed!!! Install was super easy because I watched him do it, LOL. I kid. I’ll ask for his install input and update but seriously he installed all 4 (3 bedrooms and 1 living room) in 2 days. Probably wouldn’t have taken so long if he didn’t have to pour a pad for them but it was well worth it! Last pic is from the Nest. They were installed Friday. Compare usage from Sat & Sun to before we got them! Insane!!!
This was best investment I've ever made. I put this on the wall on my porch that I've converted to a sun room. This extra space that I enclosed with plexiglass and wood and sealed with insulation stayed about 20 degrees different from out side. With a window unit and heaters. Now with the split unit it stays what ever temp I want it to be. The della split unit is so quite I have to put my ear on it to hear it run sometimes the out side unit is even quite. If you mount on outside wall that is a little thin and only a few inches thick it might give a little bit of a hum but so slight you have to want to hear it. Turbo cool or heat will cool or heat super fast. The system is perfect 👌 👍 🥰. I love it.
I live in Florida and our summers are brutal. I installed this in my garage.
It wasn’t a hard install but it took my dad and I about 8 hours. He ran the electrical.
Around this time of the year, my garage is around 82 degrees and +70% humidity, the air is very wet.
This morning it was 74” and 52% humidity.
The indoor and outdoor units are remarkably quieter compared to our house’s HVAC system.
I bought and installed 2 of the della mini splits in the last 8 months, one for my double wide 1800 sqf that I am remodeling little by little, and another for my daughters craftsman home. What an improvement! So silent! So efficient! So easy of operating. For the last 10+ years, we have been using windows AC units and radiant heaters after our central heat and air system broke. The suffering is over. We are saving $100 a month on the power bill and enjoying ourselves inside now. Our Great Pyrenees friends are enjoying the AC's too during the scorching hot summer days. They are pretty easy to install. Follow the instructions on the book and watch some videos on YouTube. On the second install, I made an electrical mistake and purchased the wrong breaker. I am only a landscaper by the way. No problem! I called the technical support number and a very nice tech called me back after just a few hours and figured it out by phone within 5 minutes. It is all great! We just keep it simple by using the remotes. I love the delay timer option. Now that the weather is cooling down (80's max), I set the timer so it doesn't come ON automatically before 12 pm. By the time the girls come from school, 75°f is back as set. GREAT PRODUCT, GREAT TECHNICAL SUPPORT
Installation was a breeze. Unit is working flawlessly. I love that it connected to my Alexa and I can voice control or use the Della app. I am going to purchase a second Della for our guest home.
Got these panels for my backyard as the wall for the Composting area. Black is good for absorbing the heat of the sun and is easy to hide the ugly things. It is a good quality product. The foot support is stainless steel and long enough to bind the ground and the panels. As it is with a good quality, it is just a little heavy, which may require two people to move around or install it.
Solid plastic material. Assembly was easy with a power screwdriver. Looks better than an ugly air conditioner unit.
Great value and just the right size. Note that if you want to place them in a straight line, you will need to use an electric screwdriver to tighten the screws.
Made from good quality materials. Very easy to install and assemble. Looks great to hide the trash bins. Would buy more for AC.
I use it to cover the trash can. It is very practical. This way you can't see the dirty surface of the trash can. I strongly recommend it.
Great product. Installation was very easy
What customers think about the store
This store offers HVAC systems, mini-splits, heat pumps, solar equipment, and accessories with competitive pricing. Customers praise fast shipping, responsive customer service, and helpful technical support. Products are well-packaged and arrive on time. Many ...